MATERIAL
SAFETY DATA SHEET
ChemFree Corporation
Tel: (770) 564-5580 Fax: (770) 564-5533 website: www.chemfree.com
Product Name: SmartWasher® OzzyMat™ FL-4 Multilayer Fluid Activation Mat
Product Use: Mat and hydrocarbon degrader for the SmartWasher system
24 H Emergency Response: HEPACO (800) 888-7869
Manufactured by: ChemFree Corporation
8 Meca Way
Norcross, GA 30093
U.S.A
PAGE 1 OF 3
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
|
HAZARDOUS |
% |
CAS # |
LD50 OF INGREDIENTS |
LC50 OF INGREDIENT |
|
INGREDIENTS |
|
NUMBER |
(SPECIES & ROUTE) |
(SPECIES & ROUTE) |
|
Non-hazardous hydrocarbon degrader mixed bacterial cultures in a vegetable base |
100 |
N/A |
N/A |
N/A |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
SECTION III
HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods Classification: Non Hazardous
hazard ratings (nfpa/hmis)
health 0 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0 4 = extreme.
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
PHYSICAL STATE: Solid SOLUBILITY IN WATER: Forms Slurry
APPEARANCE AND ODOR: Solid filter with granular powder: Buff to brown color in the middle.
Product Name: SmartWasher® OzzyMat™ FL-4 Multilayer Fluid Activation Mat PAGE 2 OF 3
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID PROCEDURES:
EYES: It is unlikely that emergency treatment will be required; if adverse effects occur, rinse eyes with large amounts of water until irritation subsides. Seek medical attention if necessary.
SKIN: It is unlikely that emergency treatment will be required; if adverse effects occur, rinse affected area with large amounts of water until no evidence of chemical remains. Seek medical attention if necessary.
INGESTION: Do not ingest.
INHALATION: It is unlikely that emergency treatment will be required; if adverse effects occur, remove to fresh air and observe. Seek medical attention if necessary.
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLASH POINT: None METHOD USED: Open cup
FLAMMABLE LIMITS:
UPPER: None
LOWER: None
SPECIAL FIRE FIGHTING PROCEDURES: None
USUAL FIRE & EXPLOSION HAZARDS: None
SECTION VII
ACCIDENTAL RELEASE MEASURES
In the event that this material is released or spilled, sweep up/collect.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
No special precautions are required. This product is not hazardous for storage and transport according to the U.S. Department of Transportation Regulations.
SECTION IX
EXPOSURE CONTROLS
Exposure Limits: This product presents no health hazards to the user when used according to label directions for its intended purposes.
VENTILATION (Local exhaust): Not required.
SECTION X
PERSONAL PROTECTION
RESPIRATORY PROTECTION (Specify Type): Not required.
PROTECTIVE GLOVES: It is recommended that rubber gloves be worn when handling any industrial-use products.
EYE PROTECTION: It is recommended that safety glasses be worn when handling any industrial-use products.
OTHER / HYGIENIC PRACTICES: Always use good housekeeping procedures when using any chemical product.
Product Name: SmartWasher® OzzyMat™ FL-4 Multilayer Fluid Activation Mat PAGE 3 OF 3
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
CONDITIONS TO AVOID: Avoid exposure to moisture. DO NOT WET UNTIL READY TO USE. Store at 32F – 105F
INCOMPATABILITY (materials to avoid): Water should be avoided until mat is installed
ROUTES OF ENTRY: Skin, Eyes
EFFECTS OF ACUTE EXPOSURE: It is unlikely that exposure will require treatment because product is considered inert.
HEALTH HAZARDS (Acute & Chronic): None
CARCINOGENICITY: None Known
TETRATOGENICITY: None known
BIODEGRADABILITY: Biodegradable
TOXICITY INFORMATION:
48 hours LC50 value in mg/L
Ceriodaphnia dubia N/A
Fathead Minnows N/A
SECTION XIV
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: Dispose of in accordance with Local, State, and Federal regulations.
SECTION XV
ADDITIONAL INFORMATION
Prepared by: Karen Graham Date: February 17, 2006