MATERIAL
SAFETY DATA SHEET
ChemFree Corporation
Tel: (770) 564-5580 Fax: (770) 564-5533 website: www.chemfree.com
Product
Name: SmartWasher® OzzyBooster™ Microbial Enhancer
Product Use: Bacterial
Innoculant for hydrocarbon degradation in the SmartWasher system
24
H Emergency Response: HEPACO (800) 888-7869
Manufactured
by: ChemFree Corporation
U.S.A
PAGE 1 OF 4
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
|
HAZARDOUS |
% |
CAS # |
LD50 OF INGREDIENTS |
LC50 OF INGREDIENT |
|
INGREDIENTS |
|
NUMBER |
(SPECIES & ROUTE) |
(SPECIES & ROUTE) |
|
Non-hazardous
hydrocarbon degrader mixed bacterial cultures in a liquid base |
100 |
N/A |
N/A |
N/A |
|
|
|
|
|
|
SECTION III
HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods
Classification: Non Hazardous
hazard ratings (nfpa/hmis)
health 1 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0
4 = extreme.
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
APPEARANCE AND ODOR: Free-flowing, blue liquid
BOILING POINT: 212F/100 C
(Approx.)
SOLUBILITY IN WATER: Soluble
Vapor Pressure (mm Hg): 24.00 (Approx.)
pH: 7.0
Product Name: SmartWasher® OzzyBooster™ Microbial Enhancer PAGE 2 OF 4
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID
PROCEDURES:
EYES: It is
unlikely that emergency treatment will be required; if adverse effects occur,
rinse eyes with large amounts of
sterile
water until irritation subsides. Seek
medical attention if necessary.
SKIN: Wash
with soap and water.
INGESTION: Low
order of toxicity. Upon ingestion,
induce vomiting and contact a physician.
INHALATION: It
is unlikely that emergency treatment will be required; if adverse effects
occur, remove to fresh air and
observe. Seek medical
attention if necessary.
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLASH POINT: None > 200 F METHOD
USED: Open cup
FLAMMABLE LIMITS: N/A
UPPER: N/A
LOWER: N/A
SPECIAL FIRE FIGHTING PROCEDURES:
None
USUAL FIRE & EXPLOSION HAZARDS:
None
SECTION VII
ACCIDENTAL RELEASE MEASURES
In the event that this material
is released or spilled, it can be washed into storm sewer with large quantities
of water.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
Protect from freezing. This product is not hazardous for storage and
transport according to the
SECTION IX
EXPOSURE CONTROLS
Exposure Limits: This product
presents no health hazards to the user when used according to label directions
for its intended purposes. Protective
water resistant gloves and safety glasses with side shields are recommended.
SECTION X
PERSONAL PROTECTION
General Precautions: Treat s you would any chemical or biological
material.
Wear protective water
resistant gloves and safety glasses with side shields.
Special Precautions: This product not intended for human or animal
consumption.
Product Name: SmartWasher® OzzyBooster™ Microbial Enhancer PAGE 3 OF 4
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS
POLYMERIZATION: Will not occur
Toxicology
Acute Studies
* Rat oral LD50 is
greater than 5 g/Kg of body weight; as evidenced by no observed mortality after
rats were dosed with 5 g/Kg at a concentration of 500 mg OzzyBooster/ml of
water and a dose volume of 10 ml/Kg of body weight.
* Rabbit dermal LD50
is greater than 2 g/Kg of body weight; as evidenced by no observed mortality
after rabbits were exposed to test material applied to abraded and non-abraded
occluded skin for 24 hours. No severe
dermal effects were reported at the dose site.
* Eye irritation in rabbits was
reported as slight. Highest observed
scores out of a possible score of 110 were:
1 hour: 12; 24 hours: 8; 48 hours: 4; 72
hours: 4; 4 days: 2; 7 days: 2;
10 days: 2; 14 days: 2.
* Rat inhalation of the test
material at an average analytical exposure concentration of 1.2 mg/1 of Ozzy
Booster (nominal concentration of 37 mg/l) for 6 hours produced no mortality.
Chronic Health Hazards
·
Although chronic studies using
OzzyBooster are not available, inhalation of this product should be prevented
due to unknown long-term effects.
Special Notes Not
for human and animal consumption.
BIODEGRADABILITY: Biodegradable
TOXICITY INFORMATION:
48 hours LC50 value in mg/L
Fathead Minnows Not
Toxic at 100%
SECTION XIV
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: Use normal
liquid waste methods in conformance with pertinent federal, state, and local
regulations.
Product Name: SmartWasher® OzzyBooster™ Microbial Enhancer PAGE 4 OF 4
SECTION XV
REGULATORY INFORMATION
Workplace classification: This product is considered non-hazardous
under the OSHA Hazard Communication Standard
SARA Title 3: None
TSCA Status:
Listed
RCRA classification:
Unknown
CERCLA reportable quantity: None Listed
Prepared by: Karen Graham
Date: December 19,
2005