MATERIAL SAFETY DATA SHEET
ChemFree
Corporation
Tel: (770) 564-5580 Fax: (770) 564-5533
|
SECTION I |
Product Name:
OzzyJuice SW-3 Truck Degreasing Solution
Product Use:
Degreasing Fluid for the SmartWasher system
24 H Emergency Response: HEPACO (800) 888-7869
Manufactured by: ChemFree Corporation
U.S.A
PAGE 1 OF
3
|
SECTION II HAZARDOUS
INGREDIENTS / INFORMATION |
|
HAZARDOUS
INGREDIENTS |
% |
CAS # |
LD50 OF INGREDIENTS (SPECIES AND ROUTE) |
LC50 OF
INGREDIENTS (SPECIES & ROUTE) |
|
Non
Hazardous water-based degreaser All
ingredients are listed on the TSCA Chemical Substance Inventory and on the
Domestic Substance List |
100% |
N/A |
N/A |
N/A |
|
SECTION III HAZARDS
IDENTIFICATION |
UN Number: Not
Required
Dangerous Goods Classification: Non-Hazardous
HAZARD RATINGS (NFPA/HMIS)
HEALTH 1 0=least
1=slight
FLAMMABILITY 0 2=moderate
3=high
REACTIVITY 0 4=extreme
|
SECTION IV FIRST AID
MEASURES |
EMERGENCY & FIRST AID PROCEDURES:
EYES: It is unlikely that emergency treatment will
be required; if adverse effects occur, rinse eyes with large
amounts
of water until irritation subsides. Seek
medical attention if necessary.
SKIN: Wash with soap and water.
INGESTION: It is unlikely that emergency treatment will
be required; if adverse effects occur, treat
symptomatically and
seek medical attention if necessary.
INHALATION: It is unlikely that emergency treatment will
be required; if adverse effects occur, remove to
fresh air and observe.
Seek medical attention if necessary.
Product Name: OzzyJuice
SW-3 Truck Grade Degreasing Solution PAGE 2 OF 3
|
SECTION V FIRE &
EXPLOSION HAZARD DATA |
FLAMMABILITY:
None
MEANS OF EXTINCTION:
N/A
FLASH POINT:
None > 200 F METHOD
USED: Open cup
FLAMMABLE LIMITS:
N/A
UPPER: N/A
LOWER: N/A
SPECIAL FIRE FIGHTING PROCEDURES: None
USUAL FIRE & EXPLOSION HAZARDS: None
|
SECTION VI ACCIDENTAL
RELEASE MEASURES |
In the event that this material is released or spilled,
it can be washed into a storm sewer with large quantities of water.
|
SECTION VII HANDLING,
STORAGE, & TRANSPORT INFORMATION |
No special precautions are required. This product is not hazardous for storage and
transport according to the
Department of Transportation Regulations.
|
SECTION
VIII EXPOSURE
CONTROLS |
Exposure Limits:
This product presents no health hazards to the user when used according
to label directions for its
intended purposes.
|
SECTION IX PERSONAL
PROTECTION |
RESPIRATORY PROTECTION (Specify Type): Not required
PROTECTIVE
GLOVES: It is recommended that rubber
gloves be worn when handing any industrial-use products.
EYE
PROTECTION: It is recommended that
safety glasses be worn when handling any industrial-use products.
OTHER /
HYGIENIC PRACTICES: Always use good
housekeeping procedures when using any chemical product.
|
SECTION X PHYSICAL /
CHEMICAL CHARACTERISTICS |
BOILING POINT:
210 F/99 C pH: 7.51
VAPOR DENSITY (AIR=1):
1.689
APPEARANCE AND ODOR:
Clear, low-odor fluid
SPECIFIC GRAVITY:
1.0182
VOC Content:
<5 g/L
|
SECTION XI STABILITY
AND REACTIVITY DATA |
REACTIVITY:
Non-reactive
STABILITY:
Stable
HAZARDOUS POLYMERIZATION: Will not occur
|
SECTION XII TOXICOLOGICAL
PROPERTIES |
ROUTES OF ENTRY:
Skin, Eyes
EFFECTS OF
ACUTE EXPOSURE: It is unlikely that exposure
will require treatment because product is considered a
dermal
non-irritant and a mild ocular irritant.
HEALTH
HAZARDS (Acute & Chronic): None
CARCINOGENICITY: None Known
TETRATOGENICITY: None Known
Product Name: OzzyJuice
SW-3 Truck Grade Degreasing Solution PAGE 3 OF 3
|
SECTION
XIII BIODEGRADABILITY
AND ENVIRONMENTAL TOXICITY INFORMATION |
BIODEGRADABILITY: Biodegradable
TOXICITY
INFORMATION:
48
hours LC50 value in mg/L
Ceriodaphnia dubia 306.49 mg/L
Fathead
Minnows 624.30
mg/L
|
SECTION XIV DISPOSAL
CONSIDERATIONS |
Dispose of in
accordance with Local, State, and Federal regulations.
Prepared
by: Karen Graham December 19, 2005