MATERIAL SAFETY DATA SHEET
ChemFree Corporation
Tel: (770) 564-5580
Fax: (770) 564-5533 website: www.chemfree.com
Product Name: OzzyJuice® SW-6LF Select Metals Degreasing Solution (Low Foam)
Product Use: Degreasing Fluid for the SmartWasher system
24 H Emergency Response: HEPACO (800) 888-7869
Manufactured by: ChemFree Corporation
8 Meca Way
Norcross, GA 30093
U.S.A
PAGE 1 OF 3
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
|
HAZARDOUS |
% |
CAS # |
LD50 OF INGREDIENTS |
LC50 OF INGREDIENT |
|
INGREDIENTS |
|
NUMBER |
(SPECIES & ROUTE) |
(SPECIES & ROUTE) |
|
Non Hazardous proprietary water based degreaser |
100 |
N/A |
N/A |
N/A |
|
All ingredients are listed on the TSCA Chemical Substance Inventory and on the Domestic Substance List |
|
|
|
|
|
|
|
|
|
|
SECTION III
HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods Classification: Non Hazardous
hazard ratings (nfpa/hmis)
health 1 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0 4 = extreme.
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
PHYSICAL STATE: Liquid SOLUBILITY IN WATER: Soluble
BOILING POINT: 210o F/99o C (Approx.) PH: 8.7
APPEARANCE AND ODOR: Clear, low odor fluid
SPECIFIC GRAVITY: 1.0046
VOC Content:
VOC composite partial pressure:
Product Name: OzzyJuice® SW-6LF Select Metals Degreasing Solution (Low Foam) PAGE 2 OF 3
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID PROCEDURES:
EYES: It is unlikely that emergency treatment will be required; if adverse effects occur, rinse eyes with large amounts of
water until irritation subsides. Seek medical attention if necessary.
SKIN: Wash with soap and water.
INGESTION: It is unlikely that emergency treatment will be required; if adverse effects occur, treat symptomatically and
seek medical attention if necessary.
INHALATION: It is unlikely that emergency treatment will be required; if adverse effects occur, remove to fresh air and
observe. Seek medical attention if necessary.
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLAMMABILITY: None
MEANS OF EXTINCTION: N/A
FLASH POINT: None > 200 F (Approx.) METHOD USED: Open cup
FLAMMABLE LIMITS: N/A
UPPER: N/A
LOWER: N/A
SPECIAL FIRE FIGHTING PROCEDURES: None
USUAL FIRE & EXPLOSION HAZARDS: None
SECTION VII
ACCIDENTAL RELEASE MEASURES
In the event that this material is released or spilled, it can be washed into storm sewer with large quantities of water.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
No special precautions are required. This product is not hazardous for storage and transport according to the U.S. Department of Transportation Regulations.
SECTION IX
EXPOSURE CONTROLS
Exposure Limits: This product presents no health hazards to the user when used according to label directions for its intended
purposes.
SECTION X
PERSONAL PROTECTION
RESPIRATORY PROTECTION (Specify Type): Not required.
PROTECTIVE GLOVES: It is recommended that rubber gloves be worn when handling any industrial-use products.
EYE PROTECTION: It is recommended that safety glasses be worn when handling any industrial-use products.
OTHER / HYGIENIC PRACTICES: Always use good housekeeping procedures when using any chemical product.
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
Product Name: OzzyJuice® SW-6LF Select Metals Degreasing Solution (Low Foam) PAGE 3 OF 3
ROUTES OF ENTRY: Skin, Eyes
EFFECTS OF ACUTE EXPOSURE: It is unlikely that exposure will require treatment because product is considered a dermal
non-irritant and a mild ocular irritant.
HEALTH HAZARDS (Acute & Chronic): None
CARCINOGENICITY: None Known
TETRATOGENICITY: None known
BIODEGRADABILITY:
TOXICITY INFORMATION:
SECTION XIV
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: Dispose of used fluid in accordance with Local, State and Federal regulations.
SECTION XV
ADDITIONAL INFORMATION
Prepared by: Karen Graham Date: April 13, 2006