MATERIAL SAFETY DATA SHEET
ChemFree Corporation
Tel: (770) 564-5580
Fax: (770) 564-5533 website: www.chemfree.com
Product
Name: OzzyJuice® SW-LF Low Foam Degreasing
Solution
Product Use: Degreasing
Fluid for the SmartWasher system
24
H Emergency Response: HEPACO (800) 888-7869
Manufactured
by: ChemFree Corporation
U.S.A PAGE
1 OF 3
SECTION II
HAZARDOUS INGREDIENTS / INFORMATION
|
HAZARDOUS |
% |
CAS # |
LD50 OF INGREDIENTS |
LC50 OF INGREDIENT |
|
INGREDIENTS |
|
NUMBER |
(SPECIES & ROUTE) |
(SPECIES & ROUTE) |
|
|
|
|
|
|
|
Non Hazardous proprietary
water based degreaser |
100 |
N/A |
N/A |
N/A |
|
All ingredients are
listed on the TSCA Chemical Substance Inventory and on the Domestic Substance
List |
|
|
|
|
|
|
|
|
|
|
SECTION III
HAZARDS IDENTIFICATION
UN Number: Not Required
Dangerous Goods Classification:
Non Hazardous
hazard ratings (nfpa/hmis)
health 1 0 = least
1 = slight
flammability 0 2 = moderate
3 = high
reactivity 0
4 = extreme.
Product
Name: OzzyJuice® SW-LF Select Metals Low Foam Degreasing
Solution
PAGE 2 OF 3
SECTION IV
PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: 210o F/99o C PH: 7.29
APPEARANCE AND ODOR: Clear, low odor fluid
VOC Content: N/A
VOC composite partial
pressure: N/A
SECTION V
FIRST AID MEASURES
EMERGENCY & FIRST AID
PROCEDURES:
EYES: It is unlikely that emergency treatment will be required; if adverse effects occur, rinse eyes with large amounts of
water until irritation subsides. Seek medical attention if necessary.
SKIN: Wash
with soap and water.
INGESTION: It is unlikely that emergency treatment will be required; if adverse effects occur, treat symptomatically and
seek medical attention if
necessary.
INHALATION: It is unlikely that emergency treatment will be required; if adverse effects occur, remove to fresh air and
observe. Seek medical attention if necessary.
SECTION VI
FIRE & EXPLOSION HAZARD DATA
FLAMMABILITY: None
MEANS OF EXTINCTION: N/A
FLASH POINT: None N/A METHOD
USED: N/A
FLAMMABLE LIMITS: N/A
UPPER: N/A
LOWER: N/A
SPECIAL FIRE FIGHTING PROCEDURES:
None
USUAL FIRE & EXPLOSION HAZARDS:
None
SECTION VII
ACCIDENTAL RELEASE MEASURES
In the event that this
material is released or spilled, it can be washed into storm sewer with large
quantities of water.
SECTION VIII
HANDLING, STORAGE & TRANSPORT INFORMATION
No special precautions are
required. This product is not hazardous
for storage and transport according to the
SECTION IX
EXPOSURE CONTROLS
Exposure Limits: This product
presents no health hazards to the user when used according to label directions
for its intended purposes.
Product
Name: OzzyJuice® SW-LF Select Metals Low Foam Degreasing
Solution PAGE 3 OF 3
SECTION X
PERSONAL PROTECTION
RESPIRATORY PROTECTION
(Specify Type): Not required.
PROTECTIVE GLOVES: It is recommended that rubber gloves be
worn when
handling any industrial-use products.
EYE PROTECTION: It is recommended that safety
glasses be worn when handling any industrial-use
products.
OTHER / HYGIENIC PRACTICES:
Always use good housekeeping procedures when
using any chemical product.
SECTION XI
STABILITY AND REACTIVITY DATA
REACTIVITY: Non reactive
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
ROUTES OF ENTRY: Skin, Eyes
EFFECTS OF ACUTE EXPOSURE: It
is unlikely that exposure will require treatment because product is considered
a dermal non-
irritant and a mild ocular
irritant.
HEALTH HAZARDS (Acute &
Chronic): None
CARCINOGENICITY: None Known
TETRATOGENICITY: None known
BIODEGRADABILITY: Biodegradable
TOXICITY INFORMATION:
48 hours LC50 value in mg/L
Ceriodaphnia dubia N/A
Fathead Minnows N/A
SECTION XIV
DISPOSAL CONSIDERATIONS
Dispose of in accordance with
Local, State and Federal regulations.
SECTION XV
ADDITIONAL INFORMATION
Prepared by: Karen Graham Date: December 19, 2005